Monday, June 29, 2009

Air Car From Tata Motors

Tata Motors, India's largest automotive company, on Feb. 5, 2007 announced that it has signed an agreement with Moteur Development International (MDI) of France, inventors of the car, to develop a car that runs on compressed air, thus making it very economical to run and be almost totally pollution free. This article in Rediff India Abroad and the MDI website gives further details.

The air engine has 4 two-stage pistons, i.e. 8 compression and/or expansion chambers on one crankshaft. The pistons work in two stages: one motor stage and one intermediate stage of compression/expansion. They have two functions: to compress ambient air and refill the storage tanks; and to make successive expansions (reheating air with ambient thermal energy) thereby approaching isothermic expansion. It has injection similar to normal engines, but uses a special crankshaft and pistons, which remain at top dead center for about 70 degrees of the crankshaft's cycle; this allows more power to be developed in the engine. The engine is powered by compressed air, stored in a carbon-fiber tank containing 90 cubic meters (3178 cubic feet) of air at 30 MPa (4500 psi).

The expansion of this air pushes the pistons and creates movement. The atmospheric temp. is used to re-heat the engine and increase the range.

The cars have the following characteristics:

• Are light weight vehicle that can reach speeds up to 220 kmph.

• MDI's vehicle's have fiberglass bodies which makes them light, silent urban car.

• The vehicles do not have normal speed gages. Instead, they will have a small computer screen

• Both ends of the seat belt are anchored to the vehicles floor for greater safety.

• The vehicle's uses a patented electric system that makes the car 20 kilos lighter and considerably quieter.

• There are no keys - just an access card that can be read by the car from your pocket.

• In the single energy mode MDI cars consume around US$1.00 (Rs 45) every 60 miles (100 km).

• There is no pollution from the car.

• The vehicle's driving range is close to twice that of the most advanced electric cars (from 200 to 180 miles (300 km) or 8 hours of operation).

• The recharging of the car will be done at gas stations in 2 to 3 minutes at a price of Rs 90, once the market is developed.

• The car also has a small compressor that can be connected to an electrical network (220V or 380V) and will recharged the tanks completely in 3 or 4 hours.

• The car's oil (a liter of vegetable) only needs to be changed every 50,000 km.

• The temperature of the exhaust is between 0 and 15 degrees below zero and can be used for air conditioning of the car.

The car will be produced in both a single engine compressed air cars, the MiniCAT and CityCAT and a dual engine hybrid, a compressed air engine plus a multi-fuel internal combustion engine.

The hybrid has been conceived as much for the city as the open road and will be available in all MDI vehicles. The engines will work exclusively with compressed air while it is running under 50 km/h in urban areas. But when the car is running at speeds over 50 km/h, the engines will switch to fuel mode. The engine will be able to use gasoline, biodiesel, natural gas, LNG, alcohol, etc. It was not clear whether the air engine would also be used as an ICE or whether two engines would be employed in the hybrid.

Engines will be available with 2, 4 and 6 cylinders. When the air tanks are empty the driver will be able to switch to fuel mode.

The car - MiniCAT - could cost around US$8,000 (Rs 350,000) in India and would have a range of around 180 miles (300 km) between refuels. The cost of a refill would be about US$2.00 (Rs 90).

Specifications: MiniCAT

The smallest and most innovative: three seats, minimal dimensions.

• Airbag, air conditioning, ABS, 3 seats, 1.5 m3.

• Dimensions: 2.65m, 1.62m, 1.64m

• Weight: 750 kg

• Maximum speed: 110 kmh

• Mileage: 200 - 300 km

• Maximum load: 270 Kg

• Recharging time: 4 hours (Mains connector)

• Recharge: 3 minutes (Air station)

CityCAT:

A more spacious car with seats which can face different directions. The vehicle's design is based on the needs of a typical family.

• Airbag, air conditioning, 6 seats.

• Dimensions: 3.84m, 1.72m, 1.75m

• Weight: 750 kg

• Maximum speed: 110 kmh

• Mileage: 200 - 300 km

• Max load: 500 Kg

• Recharge time: 4 hours (Mains connector)

• Recharge time: 3 minutes (Air station)

Although there is no official word on when the car will be commercially manufactured for India, reports say that it will be sooner than later.

The MDI headquarters are located in Luxembourg while the prototype factory is in the south of France, where 60 people are employed. According to the MDI website "At the moment the construction of the first serial production factory is being completed, at the same location."
Currently licenses for manufacture and distribution have been sold to companies in Spain, Portugal, Brazil, South Africa, India, Great Briton, France and the United States. ZevCAT has the license in the US.

Related Articles : Wheel Industry

01. Honda : What Next

02. Mahindra's Beautiful Dream XYLO running on the road
03. Mahindra and Mahindra : A New Scooter Segment
04. The car of the mile Maruti will not sell 800 in 11 cities from 2010
05. Hero Honda contributes climb up in two-wheeler sales
06. Tata's Air Car - Is it the next big thing?
07. Maruti 800 : Still run on the road
08. Once again Kawasaki-Bajaj
09. Global Car Majors to Follow Maruti Route
10. Maruti Suzuki's New Launch The Ritz - BS-IV Emission Norms
11. Is Audi Q5 pick the Indian Market?
12. Hyundai - Is a Nano Competitor?
13. Can Maruti Alto compete to Tata's Nano
14. Bajaj Bikes Runs On The Road of Africa and Europe
15. Maruti Suzuki Launches Ritz in Orissa
16. Tata Motors To Give Back Dealers Over Unsold Nano Forms
17. Skoda’s Attraction : A Small Car Runs on Indian Road in Next Year
18. What Is The Real Cost of Owning The Wonder Car - Nano?
19. Honda Jazz : An excellent car with good looks
20. Grab Discount Offers in June from Car Manufacturers in India
21. Mini Car from General Motors
22. Electric and Hybrid Cars from Tata Motors
23. Mahindra's New Variant : Xylo MPV with ABS (Anti-lock Breaking System)
24. Indian Auto Market : Best and Not-So-Best Models
25. TVS Apache RTR, M&M to bump off US Market
26. Fiat's Grande Punto : A Cool Car
27. Honda Jazz - An Excellent Car With Good Looks
28. Car AC : Tips To Tackle With Car AC
29. Mahindra's New Scorpio: A Powerful Automotive Vehicle
30. What is "Bharat IV Emission Norms"?
31. Why I like Maruti 800?
32. Toyota's Land Cruiser On Indian Roads
33. Alfa Romeo Milano : A New CAR (2010)
34. Porsche Cayenne S Hybrid (2010) CAR
35. Just Post Your Complaint Against Auto Drivers
36. You have to wait for Fiat Bravo
37. Expansion of Pre-Owned Cars Business - General Motors
38. Audi is going to Increases its Sales Force in India
39. TVS Flame SR 125 Set In Motion
40. Ford India Counts Big on Indian Market
41. More Powerful Engine of Maruti Grand Vitara
42. M&M Make up a U-Turn to Africa
43. Are You The First Lucky Nano Buyer?
44. Bajaj Launching Upgraded Pulsar 220 DTSi
45. High-tech “Flame” to Heat Up Indian Market
46. A new Spark on Beat-concept by end-2009 from General Motors
Post a Comment